Название: Experiments on the Spoilage of Tomato Ketchup
Автор: Arvill Wayne Bitting
Издательство: Public Domain
Жанр: Зарубежная классика
isbn:
isbn:
EVAPORATION AND FINISHING
The pulp is evaporated rapidly to such consistency as the grade and price will warrant, the reduction in volume being from 40 to 60 per cent. This is accomplished in about forty-five minutes. The cooking is not continued longer than is necessary, as each minute added to the cooking darkens the finished product.
If the pulp has been run through the sieving machine before cooking, the batch may be drawn off into the receiving tank for bottling. If the finishing be done after cooking, the pulp is run into a receiving vat, finished as quickly as possible, and drawn into the tank for bottling. The ketchup may be kept at a high temperature – 200° to 206° F. – in the receiving tank by means of a small steam coil, or it may be drawn to the bottling machine through a steam-jacketed tube. Finishing after cooking yields a slightly smoother ketchup than sieving before cooking; but it necessitates handling, reduces the temperature, and increases the chances of infection.
BOTTLING
The bottles should be thoroughly cleaned as ketchup will not keep if placed in bottles which have been merely rinsed to remove the straw; if the ketchup is not to be given an after process the containers should be sterilized. In the experimental work cork stoppers gave the best results and these should be sterilized in a paraffin bath at 250° F.
PROCESSING
An after treatment or process is given to bottled goods either in a water or steam bath, the important point being that the center of the bottle be raised to the desired degree of heat. If the ketchup is thin this can be effected quickly, but if it is thick and heavy the heat penetrates the ketchup with surprising slowness. In a thin ketchup the temperature may be raised from 140° to 190° F. in eighteen minutes or less when the surrounding heat is 195° F; but in a heavy ketchup it may take an hour or more to accomplish the same result. It is therefore very important that the ketchup be processed immediately after it is corked, before it has time to cool. The rate at which the heating is effected for different goods can be determined by sealing a thermometer in the cork and recording the readings.
CHARACTER OF PRODUCTS
FIRST-CLASS PRODUCTS
The factory at which the experiments were conducted has sanitary buildings and surroundings, the floors are of concrete for flushing, and the pipes used in conducting the pulp to the kitchens are porcelain-lined to prevent discoloration from the iron and to insure cleanliness. The tubes which carry the ketchup from the kettles to the receiving tank, finishing machine, and bottler are silver-plated. Not all of these measures are necessary to make a good ketchup, but they show the care exercised in making an article of good appearance and of the finest quality.
The conditions under which ketchup is made and the care with which the work is done at some of the better factories is equal to that used in the manufacture of any food product. Whole selected fruit is used, cleanliness is maintained at every point, the best grades of spices, vinegar, granulated sugar, and salt are added for flavoring, and the bottles are carefully washed. The ketchup put up under such conditions will have a bright natural color, will remain good as long as the container is unbroken, and will continue in that condition for some time after opening if kept at a fairly cool temperature.
INFERIOR PRODUCTS FROM “TRIMMING STOCK.”
In contrast with the strictly high-grade product is the great bulk of the ketchup found on the market. The material is not whole ripe tomatoes, but consists of the waste of the canning factory, commonly designated as “trimming stock,” including the green, moldy, broken, rotten, and generally unusable tomatoes, the skins, cores, and stems from the peeling tables, and the surplus juice from the filling machines, all of which may be allowed to stand during the day and be run through the cyclone in the evening. At the end of the season, the frosted and half-ripe fruits may be used. Part of this material can not be considered “sound fruit” as contemplated by the food and drugs act. The pulp is put up in barrels, preserved, and allowed to stand, possibly in the sun, until a sufficient quantity has accumulated for shipment. Old ketchup barrels may be used and be none too clean. As a result, it is not uncommon to see an inch or more of pulp in the bottom of a car at the end of shipment, caused by the blowing out of the barrel heads from fermentation. The sanitary condition of the factory may be poor, the handling of the goods be unclean, the spices be the refuse from the spice houses, the sugar be of the cheapest grade, and the bottles be only rinsed or be used without even that precaution. The ketchup is a concoction so heavily spiced with hot spices that the tomato flavor is lost and might as well be anything else. The color is normally dirty brown.
Between these two extremes are all grades, those for which whole tomatoes, unsorted, are used, those for which trimming stock is worked up promptly during the canning season, and those made from stock of unknown history. Some manufacturers work under good and some under poor sanitary conditions. There can be no doubt that with proper selection and precaution much of the by-product of the canning factory and large quantities of tomatoes which are unsuitable for canning might be used to advantage in the manufacture of ketchup; but it requires a nicety of practice not generally found at this time. The practice sometimes followed of making some ketchup from whole stock and a large quantity from refuse and using the former for advertising purposes, only serves to emphasize the fact that the goods belong to two distinct classes. One of the uses for a very considerable amount of pulp from refuse stock is the making of sauce for baked beans and other canned goods where the true character can not be observed by the consumer.
During the season tomatoes come in at times in larger quantities than can be made into ketchup promptly. The surplus must be worked up into pulp for storage and may be stored in barrels or in tin cans. The pulp stored in barrels will not have as good a color as that put into cans, and the ketchup made from either will not be as bright as that made from whole, fresh stock. The pulp put up in barrels is more liable to spoilage than that put up in cans. The difference in the cost of storage by the two methods is not very great, and some large concerns are using the can exclusively instead of the barrel.
LABELS
The labels on the ketchup bottles have been improved somewhat in the last year as regards exactness in describing the contents. Formerly, according to the labels, much of the ketchup was made from whole ripe tomatoes. The question was, What became of the enormous amount of ketchup which it was known had been made from “trimmings?” On this year’s ketchup the labels make fewer claims, generally merely stating that it is “tomato ketchup,” which is true whether made from whole tomatoes or refuse. The brand is in most cases the guaranty for good quality. It is not safe to judge the quality by the price, for, though usually good quality can not be expected unless the higher price is paid, some of the high-priced ketchup when placed under the microscope has proven to be a very inferior product.
The wide labels on the neck of the bottle are objectionable. Some of these are 2 inches in height, and serve to cover the discolored and spoiled ketchup. As spoilage begins usually in the neck of the bottle, it is difficult to see it when the neck is wrapped with a label, and thus it might easily be overlooked until the main body of the ketchup is affected. The bottles which have the widest labels around the neck are usually the ones provided with one or two large labels on the lower part of the bottle, though some bottles have no other label but the one around the neck. As a rule, however, these are narrow, close to the stopper, and unobjectionable.
In buying ketchup for experimental purposes it was difficult and sometimes impossible to learn its age, as often the grocer does not know it, and at other times he will not tell. It appeared, however, that often the ketchup had been on the grocer’s shelf or in the warehouse from СКАЧАТЬ