“And when it is in the pot,” asked Pencroft naturally, “what will it be like?”
“An excellent piece of beef,” replied Herbert.
“We will not ask more from it,” replied the sailor.
During this excursion they saw several wild boars, which however, did not offer to attack the little band, and it appeared as if they would not meet with any dangerous beasts; when, in a thick part of the wood, the reporter thought he saw, some paces from him, among the lower branches of a tree, an animal which he took for a bear, and which he very tranquilly began to draw. Happily for Gideon Spilett, the animal in question did not belong to the redoubtable family of the plantigrades. It was only a koala, better known under the name of the sloth, being about the size of a large dog, and having stiff hair of a dirty color, the paws armed with strong claws, which enabled it to climb trees and feed on the leaves. Having identified the animal, which they did not disturb, Gideon Spilett erased “bear” from the title of his sketch, putting koala in its place, and the journey was resumed.
At five o’clock in the evening, Cyrus Harding gave the signal to halt. They were now outside the forest, at the beginning of the powerful spurs which supported Mount Franklin towards the west. At a distance of some hundred feet flowed the Red Creek, and consequently plenty of fresh water was within their reach.
The camp was soon organized. In less than an hour, on the edge of the forest, among the trees, a hut of branches interlaced with creepers, and pasted over with clay, offered a tolerable shelter. Their geological researches were put off till the next day. Supper was prepared, a good fire blazed before the hut, the roast turned, and at eight o’clock, while one of the settlers watched to keep up the fire, in case any wild beasts should prowl in the neighborhood, the others slept soundly.
The next day, the 21st of April, Cyrus Harding accompanied by Herbert, went to look for the soil of ancient formation, on which he had already discovered a specimen of ore. They found the vein above ground, near the source of the creek, at the foot of one of the northeastern spurs. This ore, very rich in iron, enclosed in its fusible veinstone, was perfectly suited to the mode of reduction which the engineer intended to employ; that is, the Catalan method, but simplified, as it is used in Corsica. In fact, the Catalan method, properly so called, requires the construction of kilns and crucibles, in which the ore and the coal, placed in alternate layers, are transformed and reduced, But Cyrus Harding intended to economize these constructions, and wished simply to form, with the ore and the coal, a cubic mass, to the center of which he would direct the wind from his bellows. Doubtless, it was the proceeding employed by Tubalcain, and the first metallurgists of the inhabited world. Now that which had succeeded with the grandson of Adam, and which still yielded good results in countries rich in ore and fuel, could not but succeed with the settlers in Lincoln Island.
The coal, as well as the ore, was collected without trouble on the surface of the ground. They first broke the ore into little pieces, and cleansed them with the hand from the impurities which soiled their surface. Then coal and ore were arranged in heaps and in successive layers, as the charcoal-burner does with the wood which he wishes to carbonize. In this way, under the influence of the air projected by the blowing-machine, the coal would be transformed into carbonic acid, then into oxide of carbon, its use being to reduce the oxide of iron, that is to say, to rid it of the oxygen.
Thus the engineer proceeded. The bellows of sealskin, furnished at its extremity with a nozzle of clay, which had been previously fabricated in the pottery kiln, was established near the heap of ore. Using the mechanism which consisted of a frame, cords of fiber and counterpoise, he threw into the mass an abundance of air, which by raising the temperature also concurred with the chemical transformation to produce in time pure iron.
The operation was difficult. All the patience, all the ingenuity of the settlers was needed; but at last it succeeded, and the result was a lump of iron, reduced to a spongy state, which it was necessary to shingle and fagot, that is to say, to forge so as to expel from it the liquefied veinstone. These amateur smiths had, of course, no hammer; but they were in no worse a situation than the first metallurgist, and therefore did what, no doubt, he had to do.
A handle was fixed to the first lump, and was used as a hammer to forge the second on a granite anvil, and thus they obtained a coarse but useful metal. At length, after many trials and much fatigue, on the 25th of April several bars of iron were forged, and transformed into tools, crowbars, pincers, pickaxes, spades, etc., which Pencroft and Neb declared to be real jewels. But the metal was not yet in its most serviceable state, that is, of steel. Now steel is a combination of iron and coal, which is extracted, either from the liquid ore, by taking from it the excess of coal, or from the iron by adding to it the coal which was wanting. The first, obtained by the decarburation of the metal, gives natural or puddled steel; the second, produced by the carburation of the iron, gives steel of cementation.
It was the last which Cyrus Harding intended to forge, as he possessed iron in a pure state. He succeeded by heating the metal with powdered coal in a crucible which had previously been manufactured from clay suitable for the purpose.
He then worked this steel, which is malleable both when hot or cold, with the hammer. Neb and Pencroft, cleverly directed, made hatchets, which, heated red-hot, and plunged suddenly into cold water, acquired an excellent temper.
Other instruments, of course roughly fashioned, were also manufactured; blades for planes, axes, hatchets, pieces of steel to be transformed into saws, chisels; then iron for spades, pickaxes, hammers, nails, etc. At last, on the 5th of May, the metallic period ended, the smiths returned to the Chimneys, and new work would soon authorize them to take a fresh title.
Конец ознакомительного фрагмента.
Текст предоставлен ООО «ЛитРес».
Прочитайте эту книгу целиком, купив полную легальную версию на ЛитРес.
Безопасно оплатить книгу можно банковской картой Visa, MasterCard, Maestro, со счета мобильного телефона, с платежного терминала, в салоне МТС или Связной, через PayPal, WebMoney, Яндекс.Деньги, QIWI Кошелек, бонусными картами или другим удобным Вам способом.